compressive strength of quarry waste as coarse aggregate in concrete

  • Strength and Durability Evaluation of Recycled Aggregate

    May 14 2015 · Compressive strength Cubes (150 mm 150 mm 150 mm) were tested for compressive strength according to (ASTM 2011a) at 3 7 14 21 and 28 days strength development with time is shown in Fig. 8. Compressive strength of concrete produced with the recycled aggregate was in the range of 41 to 52 MPa. Mix 4 had the lowest compressive strength.

    Get Price
  • Compressive strength and durability properties of ceramic

    minor strength loss possess increase durability per-formance. Results also shows that concrete mixtures with ceramic aggregates perform better than the control concrete mixtures concerning compressive strength capillarity water absorption oxygen perme-ability and chloride diffusion. The replacement of cement and aggregates in concrete by

    Get Price
  • A Study of Concrete Made with Fine and Coarse Aggregates

    This paper deals with the possibility of using fresh concrete waste as recycled aggregates in concrete. An experimental program based on two variables (proportion of fine aggregates replacement and proportion of coarse aggregates replacement) was implemented. The proportions of replacement were 0 50 and 100 by mass of aggregates.

    Get Price
  • Effect of recycled concrete aggregates on strength and

    crete aggregate (RCA) on the rate of concrete compressive strength and stiffness gain with time and on the bond strength between seven-wire steel prestressing strand and concrete. The use of RCA did not have a significant effect on the rate of concrete compressive strength or stiffness gain but it did have a small effect on the strand bond

    Get Price
  • A STUDY ON PROPERTIES OF CONCRETE WITH CERAMIC

    ceramic waste in concrete is more effective in strength as well as economic aspects. Keywords Compressive strength Flexural strength Marble waste Mix design Split tensile strength Cite this Article Dr. K. Ramadevi A Study on Properties of Concrete with Ceramic Waste Replaced for Fine Aggregate International Journal of Civil Engineering and

    Get Price
  • EFFECT OF FLY ASH AND QUARRY DUST AS A PARTIAL

    to study the effect of partial replacement of fine aggregates by quarry dust and cement by fly ash on cement concrete. to compare compressive strength of normal concrete with partial replacement of fly ash Impact strength of coarse aggregate as per IS2386-part IV-1963.

    Get Price
  • Coal power station waste as a fine aggregate replacement

    Oct 10 2019 · Coal power station waste as a fine aggregate replacement in concrete. water coarse aggregates fine aggregates and admixtures which are becoming increasingly popular to enhance the properties of concrete to better suit its application. Hardened concrete Compressive strength The hardened concrete properties of the various groups

    Get Price
  • Aggregates for Concrete

    coarse aggregates generally occupy 60 to 75 of the concrete volume (70 to 85 by mass) and strongly influ- Recycled concrete or crushed waste concrete is a Compressive and flexural Acceptability of fine ASTM C 39 (AASHTO T 22) Strength to exceed 95 of

    Get Price
  • Strength of Concrete with Ceramic Waste and Quarry Dust as

    This research focuses on a study of the strength of concrete with ceramic waste as coarse aggregate and quarry dust as fine aggregate. The sources of ceramic waste and quarry dust are obtained from the industrial in Malaysia. Presently in ceramics industries the production goes as waste which is not under going the recycle process yet. In this study an attempt has been made to find the

    Get Price
  • Effects of Waste Asbestos Cement Sheet on Compressive

    Therefore I have planned to prepared some number of cubes and beams using asbestos cement sheet waste at various proportions like 0 5 10 and 15 by weight of coarse aggregate The properties for fresh concrete are tested for Compressive Strength and flexural strength

    Get Price
  • Compressive Strength of Concrete with Recycled Glass as

    In this study three types of construction waste namely floor tiles clay bricks and crushed concrete aggregate were used to replace coarse aggregate in concrete production. The effect of coarse aggregate replacement on the workability compressive strength and flexural strength Grade 30 concrete were investigated and discussed.

    Get Price
  • Construction and Demolition Waste used as Recycled

    Construction and Demolition Waste used as Recycled Aggregates in Concrete 50 70 and 100 . It was found that the compressive strength decreased at a rate proportional to the addition of recycled aggregates. Tu et al. (2006) explored the use As RA was added in increments from 0 to 100 of the coarse aggregate the

    Get Price
  • Chemical Resistance of Concrete with Ceramic Waste

    The compressive strength of the ceramic waste aggregate concrete is better and there is no considerable change in compressive strength before and after chemical attack. This is due to the material properties of ceramic waste. Ceramic waste aggregate is hard and durable material than the conventional coarse aggregate.

    Get Price
  • RECYCLED TIRES AS COARSE AGGREGATE IN CONCRETE

    focusing on tire chips as coarse aggregate replacement. One concrete control mixture was designed which well exceeds CDOT Class P concrete requirements. The coarse aggregate component of the mixture was replaced in 100 50 30 20 and 10 by volume using tire chips. The fresh concrete properties compressive strength flexural strength

    Get Price
  • Characterization of ceramic waste aggregate concrete

    pressive strength increased considerably with ceramic coarse aggregates over the control or normal concrete the more the percentage of the gravel-size materials are replaced by the ceramics. Figs. 5 and 6 show the same graphs but with the size in the ordinate axis (compressive strength/compressive strength for normal concrete). Split tensile

    Get Price
  • Characterization of ceramic waste aggregate concrete

    pressive strength increased considerably with ceramic coarse aggregates over the control or normal concrete the more the percentage of the gravel-size materials are replaced by the ceramics. Figs. 5 and 6 show the same graphs but with the size in the ordinate axis (compressive strength/compressive strength for normal concrete). Split tensile

    Get Price
  • Effect of Using Crushed Limestone in Concrete Mixes as

    compressive strength than that made with natural sand. The increase was (2-8)MN/m 2 in compressive strength. 4 The concrete produced from crushed limestone as fine aggregate have good quality of concrete and was suitable for producing concrete paving blocks. R EFERENCES 1 Alexander s K. M 1959 Strength bond journal of American Concrete

    Get Price
  • USE OF WASTE PLASTIC AS FINE AGGREGATE SUBSTITUTE

    USE OF WASTE PLASTIC AS FINE AGGREGATE SUBSTITUTE IN CONCRETE Amalu.R.G Azeef Ashraf Muhammad Hashim Rejith.K.U Vijitha.V. Under graduate Civil Engineering Students UKF College of Engineering and Technology Kollam Kerala . NITHYA KURUP

    Get Price
  • Coal power station waste as a fine aggregate replacement

    Oct 10 2019 · Coal power station waste as a fine aggregate replacement in concrete. water coarse aggregates fine aggregates and admixtures which are becoming increasingly popular to enhance the properties of concrete to better suit its application. Hardened concrete Compressive strength The hardened concrete properties of the various groups

    Get Price
  • What is the effect of coarse aggregate size in compressive

    When we design mix the concrete its target strength is much less than the compressive strength of the aggregates used in the formation. It can also be clearly seen in the mix design procedure that greater the maximum size of coarse aggregate use

    Get Price
  • Experimental Study of Compressive Strength of Recycled

    From the experimental work Experimental Study of Compressive Strength of Recycled Aggregate Concrete the following conclusion can be made Recycling and reuse of building wastes have been found to be an appropriate solution to the problems of dumping hundred of thousands tons of debris accompanied with shortage of natural aggregates.

    Get Price
  • EFFECT OF FLY ASH AND QUARRY DUST AS A PARTIAL

    to study the effect of partial replacement of fine aggregates by quarry dust and cement by fly ash on cement concrete. to compare compressive strength of normal concrete with partial replacement of fly ash Impact strength of coarse aggregate as per IS2386-part IV-1963.

    Get Price
  • Properties of Hardened Concrete Produced by Waste Marble

    Targeted Compressive Strength Values Of Concrete Produced Waste Marble Aggregate Were Achieved According To Ts Standards. But Compressive Strength Of Concretes Produced Crushed Stone Aggregate Which Was Higher Than Concrete Produced Waste Marble Aggregate At All Curing Ages. Ceylan Manca Conventi onal Concrete As Coarse Aggregat e 100

    Get Price
  • Effects of Waste Asbestos Cement Sheet on Compressive

    Therefore I have planned to prepared some number of cubes and beams using asbestos cement sheet waste at various proportions like 0 5 10 and 15 by weight of coarse aggregate The properties for fresh concrete are tested for Compressive Strength and flexural strength

    Get Price
  • Cost Effective Design of Sustainable Concrete Using Marble

    It was reported that compressive strength Flexural strength Splitting tensile strength and young s modulus of elasticity of concrete prepared with GBFS as fine aggregate and marble waste as coarse aggregate was 3 and 6 respectively higher than that of concrete with river sand as fine aggregate and marble waste as coarse aggregate.

    Get Price
  • Effects of Waste Asbestos Cement Sheet on Compressive

    Therefore I have planned to prepared some number of cubes and beams using asbestos cement sheet waste at various proportions like 0 5 10 and 15 by weight of coarse aggregate The properties for fresh concrete are tested for Compressive Strength and flexural strength

    Get Price
  • CONSTRUCTION AND DEMOLISION WASTE AS A

    the specimens for compressive strength has been calculated. Compressive strength test was conducted on cubes of 150mmX150mmX150mm cubes for the various mixes M1 M2 M3 M4 and M5 of the Recycled fine aggregate concrete are given in the below table

    Get Price
  • Concrete with enriched quarry limestone waste as a coarse

    Feb 16 2010 · Concrete with coarse aggregate defined as enriched limestone waste of grading intermediate between the coarse and fine aggregates is characterized by specified compressive strength and modulus of rupture up to 5 000 psi and more than 750 psi respectively and is an enriched by-product of the manufacture of crushed limestone of regular sizes finer than 9.5 mm. and includes

    Get Price
  • A Study of Concrete Made with Fine and Coarse Aggregates

    This paper deals with the possibility of using fresh concrete waste as recycled aggregates in concrete. An experimental program based on two variables (proportion of fine aggregates replacement and proportion of coarse aggregates replacement) was implemented. The proportions of replacement were 0 50 and 100 by mass of aggregates.

    Get Price
  • An Experimental study on compressive strength of Quarry

    is found that 50 replacement of fine aggregate by quarry dust gives maximum result in strength than normal concrete and then decreases after replacement of fine aggregate. . Key Words fine aggregate quarry dust compressive strength replacement. 1. INTRODUCTION Quarry dust is a byproduct of the crushing process which is a

    Get Price
  • COMPARATIVE ANALYSIS OF CONCRETE STRENGTH

    locally sourced gravel in Nigeria. Aginam et al. (2013) investigate various coarse aggregate impacts on the compressive strength of concrete in South-East Nigeria. The experimental study revealed that unwashed gravel produced the least compressive strength of 16.9kN/m2 compared to 20.0kN/m2 of washed gravel. They deduced that there is a

    Get Price
  • International Journal for Research in Applied Science

    To study and compare the behaviour of concrete using ceramic waste as coarse aggregate experimental investigations as mentioned were carried out on concrete samples for their strength properties. To compare the test results control concrete with crushed stone as coarse aggregate was tested for all replacement.

    Get Price
  • A Study on the Utilization of Coconut Shell as Coarse

    coarse aggregate in gradation of 0 25 50 75 and 100 . It was observed that the compressive strength of the concrete decreased as the percentage of the shells increased in the mixes. However concrete obtained from coconut shell aggregate exhibited a higher compressive strength than palm

    Get Price
  • Concrete production using recycled waste plastic as aggregate

    Laboratory testing showed that the 28-day compressive strength of concrete containing plastic aggregates at different percentages of 10 to 50 ranged from 7000 to 2800 psi while the splitting

    Get Price
  • Compressive Strength of Lightweight Concrete IntechOpen

    This chapter has been prepared with the hope that its readers will become interested in lightweight concrete (LWC). Therefore after a brief background of lightweight concrete different types of LWC will be introduced and then LWC made of lightweight aggregates (LWA) will be specifically discussed. Compressive strength and density of LWC are the main points of interest in this chapter.

    Get Price
  • Strength of Recycled Concrete Made From Crushed Concrete

    Compressive strength of hardened concretes made from recycled concrete coarse aggregates was studied as a function Of the compressive strength of original concretes from which the coarse aggregates were derived Also studied were properties of fresh concretes made from recycled aggregates gradings of crusher products properties of recycled

    Get Price